Overview
The Bar Lev Line evolved from a group of rudimentary fortifications placed along the canal line. In response to Egyptian artillery bombardments during the War of Attrition, Israel developed the fortifications into an elaborate defense system spanning 100 miles (160 km) along Suez Canal, with the exception of the Great Bitter Lake (where a canal crossing was unlikely due to the width of the lake). The Bar Lev Line was designed to defend against any major Egyptian assault across the canal, and was expected to function as a "graveyard for Egyptian troops".
The line, costing around $300 million in 1973, was named after Israeli Chief of Staff Haim Bar-Lev. The line was built at the Suez Canal, a unique water barrier that Moshe Dayan described as "one of the best anti-tank ditches in the world." The line incorporated a massive, continuous sand wall lining the entire canal (except for the Bitter Lake), and was supported by a concrete wall. The sand wall, which varied in height from 20–25 metres (66–82 ft), was inclined at an angle of 45–65 degrees. The sand wall and its concrete support prevented any armored or amphibious units from landing on the east bank of the Suez Canal without prior engineering preparations. Israeli planners estimated it would take at least 24 hours, probably a full 48 hours for the Egyptians to breach the sand wall and establish a bridge across the canal.
Immediately behind this sand wall, was the front line of Israeli fortifications. After the War of Attrition, there were 22 forts, which incorporated 35 strongpoints. The forts were designed to be manned by a platoon. The strongpoints, which were built several stories into the sand, were on average situated less than 5 km (3 mi) from each other, but at likely crossing points they were less than 900 metres (3,000 ft) apart. The strongpoints incorporated trenches, minefields, barbed wire and a sand embankment. Major strongpoints had up to 26 bunkers with medium and heavy machineguns, 24 troop shelters, six mortar positions, four bunkers housing anti-aircraft weapons, and three firing positions for tanks. The strongpoints were surrounded by nearly fifteen circles of barbed wire and minefields to a depth of 200 metres (660 ft). A strongpoint's perimeter averaged 200–350 metres (660–1,150 ft). The bunkers and shelters provided protection against anything less than a 1,000 pound bomb, and offered luxuries to the defenders such as air conditioning. Between 500–1,000 metres (1,600–3,300 ft) behind the canal, there were prepared firing positions designed to be occupied by tanks assigned to the support of the strongpoints. Some of the names of the strongpoints were Tasa, Maftzach, Milano, Mezach, Chizayon, Mifreket, Orcal, Budapest (the largest), Nisan, Lituf, Chashiva. In addition, there were eleven strongholds located 5–8 km (3–5 mi) behind the canal, which were built along sandy hills. Each stronghold was designed to hold a company of troops. To take advantage of the water obstacle, the Israelis installed an underwater pipe system to pump flammable crude oil into the Suez Canal, thereby creating a sheet of flame. Some Israeli sources claim the system was unreliable and only a few of the taps were operational. Nevertheless, the Egyptians took this threat seriously and, on the eve of the war, during the late evening of 5 October, teams of Egyptian frogmen blocked the underwater openings with concrete.
To support the Bar Lev Line, Israel built an elaborate system of roads. Three main roads ran north-south. The first was the Lexicon Road (Infantry Road), running along the canal, which allowed the Israelis to move between the fortifications and conduct patrols. The second was the Artillery Road, around 10–12 km (6–7 mi) from the canal. Its name came from the twenty artillery and air defense positions located on it: it also linked armored concentration areas and logistical bases. The Lateral Road (Supply Road), 30 km (19 mi) from the canal, was meant to allow the concentration of Israeli operational reserves which, in case of an Egyptian offensive, would counterattack the main Egyptian assault. A number of other roads running east to west, Quantara Road, Hemingway Road, and Jerusalem Road, were designed to facilitate the movement of Israeli troops towards the canal.
The defense of the Sinai depended upon two plans, Dovecote (שׁוֹבָךְ יוֹנִים/Shovakh Yonim) and Rock (סֶלַע/Sela). In both plans, the Israeli General Staff expected the Bar-Lev Line to serve as a "stop line" or kav atzira— a defensive line that had to be held at all cost. As noted by an Israeli colonel shortly after the War of Attrition, "The line was created to provide military answers to two basic needs: first, to prevent the possibility of a major Egyptian assault on Sinai with the consequent creation of a bridgehead which could lead to all-out war; and, second, to reduce as much as possible the casualties among the defending troops."
Israeli planning was based on a 48-hour advance warning by intelligence services of an impending Egyptian attack. During these 48-hours, the Israeli Air Force would assault enemy air defense systems, while Israeli forces deployed as planned. The Israelis expected an Egyptian attack would be defeated by armored brigades supported by the superior Israeli Air Force.
Dovecote tasked a regular armored division to the defense of the Sinai. The division was supported by an additional tank battalion, twelve infantry companies and seventeen artillery batteries. This gave a total of over 300 tanks, 70 artillery guns, and 18,000 troops. These forces, which represented the Sinai garrison, were tasked with the mission of defeating an Egyptian crossing at or near the canal line. It called for around 800 soldiers to man the forward fortifications on the canal line. Meanwhile, along Artillery Road, a brigade of 110 tanks was stationed with the objective of advancing and occupying the firing positions and tanks ramparts along the canal in case of an Egyptian attack. There were two additional armored brigades, one to reinforce the forward brigade, and the other to counterattack the main Egyptian attack.
Should the regular armored division prove incapable of repulsing an Egyptian attack, the Israeli army would activate Rock, mobilizing two reserve armored divisions with support elements; implementation of Rock signified a major war.
Read more about this topic: Bar Lev Line